Experimental study on biomass (eucalyptus spp.) gasification in a two-stage downdraft reactor by using mixtures of air, saturated steam and oxygen as gasifying agents

Cristina Ap Vilas Bôas de Sales, Diego Mauricio Yepes Maya, Electo Eduardo Silva Lora, René Lesme Jaén, Arnaldo Martín Martínez Reyes, Aldemar Martínez González, Rubenildo Vieira Andrade, Juan Daniel Martínez

    Research output: Contribution to journalArticlepeer-review

    81 Scopus citations

    Abstract

    In this work, biomass (eucalyptus spp.) gasification has been investigated in a two-stage downdraft reactor by using different gasifying agents such as: air, air + saturated steam, and O2 + saturated steam. The utilization of low quality saturated steam for gasification in different mixtures with air and O2 is the main novelty of this paper. Thus, the influence of different gasifying agents was assessed on the concentrations of CO, H2 and CH4 and hence, on the lower heating value (LHV), the syngas power and the cold gasification efficiency. Since the type and flow of gasifying agent control the biomass consumption in downdraft gasifiers, the equivalence ratio (ER) and the steam-to-biomass ratio (SBR) were calculated by means of a mass balance. The results showed that low quality steam can increase remarkably the H2 concentration and the LHV of syngas despite its low temperature. Particularly, when O2 + saturated steam is fed to the gasifier, the H2 concentration varied between 27.4 and 35.9 vol.%, while the LHV was between 7.13 and 8.35 MJ/N m3, i.e. almost twice the produced when only air or air + saturated steam is used. The optimum ER seems to be below 0.412, while the SBR is found between 0.495 and 1.032. Under this conditions, the cold gasification efficiency was between 70 and 75%. Moreover, the O2 seems to mitigate in a better way the negative effect of the low temperature of the saturated steam given the lower tar concentration in syngas (58.74–64.18 mg/N m3) respect to those found with air + saturated steam (91.41–91.95 mg/N m3). This paper concludes that saturated steam can be used blended either with air or O2 (being better with O2) for biomass gasification in two-stage downdraft reactors and therefore, the requirements of superheated steam are not so important as in other gasification processes.

    Original languageEnglish
    Pages (from-to)314-323
    Number of pages10
    JournalEnergy Conversion and Management
    Volume145
    DOIs
    StatePublished - 2017

    Bibliographical note

    Funding Information:
    The authors would like to thank the Energy Company of Minas Gerais (CEMIG), the Minas Gerais State Secretary of Science and Technology (SECTES) for the financial support received for the development of this project. We also thank the Committee on Coordination of Improvements in Higher Education (CAPES), the National Research Council of Brazil (CNPq) and the Foundation for the Support of Researches of the State of Minas Gerais (FAPEMIG) for financial support.

    Publisher Copyright:
    © 2017 Elsevier Ltd

    Keywords

    • Biomass
    • Gasification
    • Hydrogen
    • Syngas
    • Two-stage gasifier

    Fingerprint

    Dive into the research topics of 'Experimental study on biomass (eucalyptus spp.) gasification in a two-stage downdraft reactor by using mixtures of air, saturated steam and oxygen as gasifying agents'. Together they form a unique fingerprint.

    Cite this